Call us: +44 (0)1634 300900 | E-mail: sales@dpie.com

Diamond Point International

Connect Tech Xtreme/GbE 24-Port - PC/104 Sized 24 Port Gigabit Ethernet Switch

Managed 24-Port Gigabit Ethernet Switch with Wide Voltage Input

Connect Tech Xtreme/GbE 24-Port - PC/104 Sized 24 Port Gigabit Ethernet Switch
Key Features
PC/104 sized 24 port Gigabit switch
Built-in controller for config/management
RS-232 management port
8K MAC addresses and 4K VLANs
Jumbo frame support at all speeds
Latching connectors for ruggedness
-40 to +85ºC operating temperature

Introduction

Connect Tech’s Xtreme/GbE 24-Port Managed Carrier Ethernet Switch provides high density, high port count, Carrier Grade Ethernet switching capabilities in an extremely small embedded form factor. Excellent for any space constrained, mission-critical application needing an embedded high-density/high-port count managed Ethernet Switch.

The Xtreme/GbE 24-Port Managed Carrier Ethernet Switch implements on-board magnetics for all 24 ports, so no external magnetics are required for your end application. It has been designed from the ground up to ease enclosure/chassis integration by limiting the amount of cabling required for port termination with the ability to remove all cabling entirely.

The Xtreme/GbE 24-Port Managed Carrier Ethernet Switch uses a specialized high density Board-to-Board/Board-to-Cable configuration for port breakouts. Ports can be broken out via a breakout board / carrier that can mate directly to the XDG024/25 or by mating to a high density high-speed Twinax cable.

The XDG025 is designed for standalone applications, with all thermal extraction on one layer and connector/ cabling on the opposite layer, where as the XDG024 is intended to stack directly into a PCIe/104 stack. 

Xtreme/GbE 24-Port Feature Highlights

  • 24 Port Gigabit Ethernet (10/100/1000 Mbps) Switch
  • All 24 Port Magnetics Integrated on-board
  • High-Density Ruggedized Board-to-Board/Board-to-Cable Port Breakout
  • Extremely Small Footprint 90×96 mm (3.550×3.775 inches)
  • Conduction cooled Heatplate or Air cooled Heatsink Options
  • Extended Temperature Range -40°C to +85°C

Specification

Main Specification

Function802.1Q VLAN switch with 8K MACs and 4K VLANs
Push/pop up to two VLAN tags
IPv4/IPv6 multicast
Policing with storm control and MC/BC protection
RSTP and MSTP support
Hardware and software-based learning
Link aggregation (IEEE 802.3ad)
Independent and shared VLAN learning (IVL, SVL)
Jumbo frame support
Standalone Operation (Switch can be used as a standalone unit OR can be paired with an embedded SBC)
Interface(s)24 x Gigabit Ethernet (10/100/1000 Mbps)
• 12 x Cu PHY Ports from Vitesse VSC7429 Switch Engine
• 12 x Cu PHY Ports from Vitesse VSC8512 External PHY
On-board Gigabit Magnetics for all 24 Ports (No external Magnetics required)
Controller(s)Vitesse VSC7429 Carrier Grade Ethernet Switch Chipset
1Gb DDR2 SDRAM, 128Mb Serial NOR Flash

Management Access:
• Web Interface
• RS-232 Serial Interface (CLI)
• Software API
• SNMP
• PCIe/104 Bus (XDG024 version only)
Connection(s)3 x High-Density Board-to-Board / Board-to-Cable Connectors
Each High-Density Connector Contains 8 Gigabit Ports
Connectors can be mated directly to breakout boards, or via cabling

Breakout Board Options:
• Direct Board-to-Board (No Cabling) to 24-Port Vertical RJ-45’s
• 8-Port Bank Cabling Options to Panel Mount Vertical RJ-45s, Right Angle RJ-45s or MIL Circular connectors
• Full Custom (Simple 2-layer no magnetics designs)

General

ExpansionPCIe/104 bus (XDG024 only - sourcing power and management interface)
Electrical+4V to 14V Input Range (External Connector) OR +12V only (from PCIe/104 Connector)
MechanicalStandard PC/104: 3.55" x 3.775" (90mm x 96mm)
Tallest Top Side Component: Heatsink 0.375” (9.5mm)
Conformal CoatingOn request
SoftwareThe switch is ready to plug into your application without any driver installation or firmware upgrades
A web interface and a CLI provide an intuitive GUI for configuring and managing the switch
TemperatureTemperature range (operation): -40°C to +85°C (-40°F to +185°F)
Temperature range (storage): -40°C to +85°C (-40°F to +185°F)
Humidity(operation) 10% - 90% relative humidity (non-condensing)
(storage) 5% - 95% relative humidity (non-condensing)
Warranty2 Years
RoHSCompliant

Ordering Details

BoardXDG024
Xtreme/GbE 24-Port Managed Carrier Ethernet Switch with PCIe/104 management expansion

XDG025
Xtreme/GbE 24-Port Managed Carrier Ethernet Switch, no expansion
AccessoriesN/A